할리 고장진단 체크 방법 및 에러 코드 안내

[제이스]

바이크가 이상할 때

에러코드 체크를 하는 방법입니다.

어디가 어떻게 문제인지 알수 있어서 편하네요.

DIAGNOSTICS 진단 방법

진입 방법

run/stop 스위치 run

게기판 트립 스위치를 누른 상태에서 이그니션 온

나오는 방법

키 OFF

3/11 추가 내용

 

에러 코드 나왔을 때 클리어 (에러코드지우는거) : 해당 코드에서 트립 버튼을 5초누르면 클러어됨

키 off 후 도로주행을 한 다음 같은 에러가 뜨는지 확인함.

바이크 상태 또는 중고 매물 확인시 diag 를 확인 한 다음

주행 후 다시 diag를 확인함.

할리 기종 마다 표시 방식이 약간의 차이는 있으나 대부분 확인이 가능합니다.

에러 코드

B0563 Battery Voltage High TSM/TSSM

B1004 Fuel Level Sending Unit Low Instruments

B1005 Fuel Level Sending Unit High/Open Instruments

B1006 Accessory Line Overvoltage Instruments

B1007 Ignition Line Overvoltage Instruments

B1008 Reset Switch Closed Instruments

B1121 (TSM) Left Turn Output Fault - (HFSM) Left Turn Output Open

B1122 (TSM) Right Turn Output Fault - (HFSM) Right Turn Output Open

B1123 (HFSM) Left Turn Output Short to Ground

B1124 (HFSM) Right Turn Output Short to Ground

B1125 (HFSM) Left Turn Output Short to Battery

B1126 (HFSM) Right Turn Output Short to Battery

B1131 (HFSM) Alarm Output Low

B1131 Alarm Output Low TSM/TSSM

B1132 (HFSM) Alarm Output High

B1132 Alarm Output High TSM/TSSM

B1134 Starter Output High TSM/TSSM

B1135 Accelerometer Fault TSM/TSSM

B1136 (HFSM) Accelerometer Tip Test Error

B1141 (TSM) Ignition Switch Low/Open - (HFSM) Ignition Switch Low/Open

B1142 Smart Security System Internal Fault

B1143 (HFSM) Security Antenna Short to Ground

B1144 (HFSM) Security Antenna Short to Battery

B1145 (HFSM) Security Antenna Open

B1151 Bank Angle Sensor(BAS) Short to Ground

B1151 Sidecar BAS Low TSM/TSSM

B1152 Bank Angle Sensor(BAS) Short to Battery

B1152 Sidecar BAS High TSM/TSSM

B1153 Bank Angle Sensor(BAS) High

B1153 Sidecar BAS Out of Range TSM/TSSM

B1154 Clutch Switch Input Short to Ground

B1155 Neutral Switch Input Short to Battery

P0106 MAP Sensor Rate of Range Error Carb

P0107 Map Sensor Failed Open/Low Carb

P0107 Map Sensor Open/Low EFI

P0108 Map Sensor Failed High Carb

P0108 Map Sensor High

P0108 Map Sensor High EFI

P0112I AT Sensor Voltage Low EFI

P0112I AT Voltage Low

P0113I AT Sensor Voltage Open/High EFI

P0113I AT Voltage Open/High

P0117 ET Sensor Low

P0117 ET Sensor Voltage Low EFI

P0118 ET Sensor High

P0118 ET Sensor Voltage Open/High EFI

P0120 TPS1 Range Error

P0122 TP Sensor Open/Low EFI

P0122 TPS1 Low

P0123 TP Sensor High EFI

P0123 TPS2 High/Open

P0131 Front Oxygen Sensor Low

P0132 Front Oxygen Sensor High

P0134 Front Oxygen Sensor Inactive

P0151 Rear Oxygen Sensor Low

P0152 Rear Oxygen Sensor High

P0154 Rear Oxygen Sensor Inactive

P0220 TPS2 Range Error

P0222 TPS2 Low

P0223 TPS2 High/Open

P0261 Front Injector Open/Low

P0262 Front Injector High EFI

P0263 Rear Injector Open/Low EFI

P0264 Rear Injector High EFI

P0371 Crank Position Sensor (CKP)

P0372 Crank Position Sensor (CKP)

P0373 CKP Sensor Intermittent

P0374 CKP Sensor Not Detected Carb

P0374 CKP Sensor Synch Error EFI

P0444 Purge Solenoid Open/Low

P0445 Purge Solenoid High

P0501 VSS Sensor Low

P0502 VSS High/Open

P0505 Loss of Idle Sped Control EFI

P0562 Battery Voltage Low

P0563 Battery Voltage High

P0572 Brake Switch Low

P0577 Cruise Control Input High

P0602 Calibration Memory Error Carb

P0603 ECM EEPROM Memory Error

P0603 EEPROM Failure Carb

P0604 RAM Failure Carb

P0605 ECM Flash Error EFI

P0605 ECM FLASH Memory Error

P0605 Program Memory Error Carb

P0607 Converter Error Carb

P06415 V+Vref 1 Out Of Range

P06515 V+Vref 2 Out Of Range

P1001 System Relay Coil Open/Low

P1002 System Relay Coil High/Shorted

P1003 System relay contacts open

P1004 System Relay Contacts Closed

P1009 Incorrect Password

P1010 Missing Password

P1270 TGS Validation Error

P1351 Front Ignition Coil Driver Open/Low

P1352 Front Ignition Coil Driver High/Shorted

P1353 Front Cylinder No Combustion

P1354 Rear Ignition Coil Driver Open/Low

P1355 Rear Ignition Coil Driver High/Shorted

P1356 Rear Cylinder No Combustion

P1357 Front Cylinder Combustion Intermittent

P1358 Rear Cylinder Combustion Intermittent

P1475 Exhaust Actuation Position Error

P1477 Exhaust Actuator Open/Low

P1478 Exhaust Actuator Shorted/High

P1501 Jiffy Stand Sensor Low

P1502 Jiffy Stand Sensor High

P1510 EFI Limited Performance Mode

P1511 EFI Power Management Mode

P1512 EFI Forced Idle Mode

P1514 Air Flow Fault

P1600 EFI Module Processor Internal Error

P2100 EFI Motor Circuit Open

P2101 EFI Motor Circuit Range Performance (Actuation Error)

P2102 EFI Motor Circuit Low

P2103 EFI Motor Circuit High

P2105 EFI Forced engine shutdown

P2107 EFI Module Processor Internal Fault

P2119 EFI Motor Throttle Body Range Performance

P2122 TGS1 Low/Open

P2123 TGS1 High

P2127 TGS2 Low/Open

P2128 TGS2 High

P2135 TPS Correlation Error

P2138 TGS Correlation Error (Twist grip sensor)

P2176 EFI Closed Position Not Learned

U1016 Loss of ECM Vehicle Speed, Vehicle Inhibit Motion or Powertrain Security StatusTSM/TSSM

U1016 Loss of ICM/ECM Serial Data Instruments

U1064 Loss of TSM/FSFM Serial Data to ICM / ECM

U1064 Loss of TSM/TSSM Serial Data Instruments

U1097 Loss of Speedometer Serial data Carb

U1097 Loss of Speedometer Serial data EFI

U1097 Loss of Speedometer Serial Data to ECM

U1097 Loss of Speedometer Serial data TSM/TSSM

U1255 Missing Message at Speedometer EFI

U1255 Serial Data Error

U1255 Serial Data Error/Missing Message EFI

U1255 Serial Data Error/Missing Message Instruments

U1255 Serial Data Error/Missing Message TSM/TSSM

U1300 ECM Serial Data Low

U1300 Serial Data Low

U1300 Serial Data Low Instruments

U1300 Serial Data Low TSM/TSSM

U1301 Serial Data Open/High Carb

U1301 Serial Data Open/High EFI

U1301 Serial Data Open/High Instruments

U1301 Serial Data Open/High TSM/TSSM

스포스터

2000-2004 캬브레터

코드 표시

odd 엑정에 첫번째 코드가 뜸

트립스위치를 한번더 누르면 두번째 코드가 뜬다.

다이그노스틱 상태에서 트립 스위치를 5초 이상 누르면

코드 표시가 지워짐

코드 읽는 방법

예 d08이면 d08로 읽으면 되고

d08set 이면 셋된 것이고

d08CLr 이면 클리어된것임

빠져나오는 방법

다이그노스틱에서 이그니션 현재 온이므로  off 하고 다시 온하거나

(리셋(트립)은 누르지 않고)

속도가 5마일이상 감지되면 풀림. 또는 이그니션 OFF

모든 코드가 표시되고나면 14 번 뜸.

코드 안내

d01 - Speed sensor power output shorted low

d02 - Speed sensor power output shorted high or open

d03 - Not Used

d04 - Not Used

d05 - Speed sensor return shorted high

d06 - Speed sensor return shorted low

d07 - Not Used

d08 - Speedometer power over voltage

d09 - Speed output shorted high

d10 - Speed output shorted low or open

CAL XX - Speedometer application calibration number:

14 = Domestic

15 = HDI

스포스터

2005-2008 인젹센

표시 안내

진입하면 모든 표시 램프가 점등됨.

밧데리,시큐리티,연료경고등,엔진경고등

트립 스위치 한번 누르면 엑정에 PSSPt 글자중 P 점멸됨

즉 한번씩 누르면 P-S-SP-t-P 루프

P = ECM/ICM (Electronic Control Module [EFI] / Ignition 

Control Module [Carburetor])

S = TSM/TSSM (Turn Signal/ Turn Signal Security Module)

SP = speedometer

T = tachometer

용어 안내

ATS - Air Temperature Sensor

BAS - Bank Angle Sensor

CCM - Cruise Control Module

CKP - Crank Position Sensor. The CKP generates an 'AC signal' 

which is sent to the ECM where it is used to reference engine 

position (TDC) and speed.

DTC - Diagnostic Trouble Codes

ECM - Electronic Control Module. (The Computer) Computes the 

spark advance for proper ignition timing and fuel control 

based on sensor inputs (from CKP, MAP & TP sensors) and 

controls the low-voltage circuits for the ignition coils and 

injectors. The dwell time for the ignition coil is also 

calculated in the microprocessor and is dependent upon battery 

voltage. The programmed dwell feature gives adequate spark at 

all speeds.

ECT - Engine Coolant Temperature. Sensor also controls the 

cooling fan relay that provides 12 Vdc to the fans.

EFI - Electronic Fuel Injection

EFP - Electronic Fuel Pump

ET - Engine Temperature sensor

FI - Fuel Injectors

FPR - Fuel Pressure regulator

IAC - Idle Air Control actuator

IAT - Intake Air Temperature sensor

ISS - Ion Sensing System detonation detection

MAP - manifold Absolute Pressure sensor. The MAP sensor 

monitors the intake manifold pressure (vacuum) and sends the 

information to the ECM.

The EMC then adjusts the spark and fuel-timing advance curves 

for optimum performance. TP - Throttle Position Sensor

TSM/TSSM (Turn Signal/ Turn Signal Security Module)

VE - Volume Efficiency

VSS - Vehicle Speed Sensor. Used as an input for idle speed control

[디커왕]

좋은 정보 정말 감사합니다.
퍼갑니다.

[제이스]

네에... 이런거라도 참고해서 추측해야 눈탱이는 않맞을 듯 해요. 즐거운 주말 보내세요~

[제이스]

ㅠㅠ 나 코드 2개나 떳음 ;; cpk랑 tps 쪽인데 음 파로님 글에는 주행 후 다시 한번 측정 해 보래...

미챠.

[제이스]

P0122 TPS1 Low

P0374 CKP Sensor Synch Error EFI

스로틀 포지션 센서

크랭크 포지션 싱크 에러

역시 알피엠 문제와 관련이 있는듯 혀... 도깨비꽁지님이 알려준거임~

[제이스]

ㅋ 미안...

[앨리스]

스크랩 해갈께요~~

[블루싼]

좋은정보감사합니다...스크랩해갈께요...^^

[G9人]

소중한 정보 감사합니다.^^

[레드존]

좋은 정보잘 보고 감니다

[Bowman]

좋은정보 감사합니다. 스크랩 합니다.

[삐삐]

좋은정보 감사 합니다..^^

[제이스]

본문 추가 내용 확인 하시고 클러어 후 다시 측정해 보세요.

[일출]

좋은 정보 감사합니다.스크랩해갑니다. ^^

[울트라클래식]

너무 좋은 정보를 찾았습니다
감사합니다
소중한 자료 참조 하겠습니다

[헙허리가]

좋은 정보 ㄳ합니다.^